The following warnings occurred:
Warning [2] Undefined variable $search_thread - Line: 60 - File: showthread.php(1617) : eval()'d code PHP 8.1.28 (Linux)
File Line Function
/inc/class_error.php 153 errorHandler->error
/showthread.php(1617) : eval()'d code 60 errorHandler->error_callback
/showthread.php 1617 eval




Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Cylinder Head Gasket Replacement? ?
#3
(02-11-2018, 05:14 PM)Paul t Wrote: 1937 Ruby Saloon ARR: 
Following a radiator refurb & replacement of  side branch studs / gasket I added antifreeze & checked for leaks.
All appeared to be in order. However after a few days I found the sump was filling up. The antifreeze had presumeably found a low spot between the cylinder head / block / gasket where before no such problem had been experienced. 
I am yet to remove the head. 
As there was no leak prior to the introduction of the antifreeze will I get away with just replacing the gasket?  Huh
When replacing the gasket is a jointing compound required? I have been advised that greasing the gasket is an option which helps with future separation of the gasket from the head /block . 
Some advice on the above would be greatly appreciated.
I used to grease head gaskets lightly and fit and only very occasionally experienced a leak.
Now I use Copper silicone (halfords) sparingly on the good advice of Steve Jones, I then leave 24 hrs before filling with coolant.
 Since the change of procedure never had a leak on any car head gasket (done quite a lot).
Torquing down is important 20ft lb cold and a re-torque after the first run.
Your torque wrench needs to be good at that sort of range ( I use a small Snap On).
I have come to the conclusion that the  "modern" seven gasket's middle sandwich is harder than originally,
so they might be a little less forgiving. 
I might be talking rubbish here !
Reply


Messages In This Thread
Cylinder Head Gasket Replacement? ? - by Paul t - 02-11-2018, 05:14 PM
RE: Cylinder Head Gasket Replacement? ? - by Nick Turley - 02-11-2018, 07:03 PM
RE: Cylinder Head Gasket Replacement? ? - by JonE - 15-01-2019, 08:36 PM

Forum Jump:


Users browsing this thread: 2 Guest(s)